LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Ford >> 2002 >> Crown Victoria Base, 4.6 9 >> Repair and Diagnosis (Single Page) >> Engine Performance >> Engine Controls - Pin Voltage Charts >> PID Definitions & Pin Voltage/PID Values >> Pin Voltage/PID Value Tables >> Escort & ZX2 >> ZX2 2.0L 4V M/T

ZX2 2.0L 4V M/T

ESCORT 2.0L 4V M/T - INPUTS

PCM Pin No./PID Only Sensors/Inputs Units Measured/PID KOEO/PID Hot Idle/PID 30 MPH/PID 55 MPH/PID
12 FLI V/FLI DCV/Percent 1.7/50 1.7/50 1.7/50 1.7/50
13 FEPS DCV .5-.6 .5-.6 .5-.6 .5-.6
21 CKP (+) Hz 0 400-425 700-900 1150-1400
31 PSP V/PSP DCV/HIGH-LOW .5/LOW 2.5/HIGH (1) .5/LOW .5/LOW
35 O2S12 DCV .1 (2) (2) (2)
38 ECT DCV/°F .4-1.0/160-200 .4-1.0/160-200 .4-1.0/160-200 .4-1.0/160-200
39 IAT DCV/°F 1.7-3.5/50-120 (3) 1.7-3.5/50-120 (3) 1.7-3.5/50-120 (3) (3) 1.7-3.5/50-120
40 FPM DCV/Percent 3.5/50 3.5/50 3.5/50 3.5/50
41 ACCS DCV/OFF-ON .1/OFF VBAT/ON (4) .1/OFF .1/OFF
57 KS DCV 2.5 2.5 2.5 2.5
58 VSS (+) Hz/MPH 0 0 65/30 125/55
60 O2S11 DCV 0 Switching (5) Switching (5) (5) Switching
63 FRPV/FRP DCV/psi 3.35/50 2.8/39 2.8/39 2.8/39
62 FTP V/FTP DCV/In. H2 O 2.6/0 2.6/0 2.6/0 2.6/0
64 CPP/PNP DCV/OFF-ON 5/OFF .1/ON (6) 5/OFF 5/OFF
85 CID Hz 0 5-7 11-15 16-21
86 ACP DCV/OPEN-CLOSED VBAT/OPEN VBAT/OPEN VBAT/OPEN VBAT/OPEN
88 MAF V DCV 0 .6-.9 1.0-1.6 1.3-2.3
89 TP V DCV .53-1.27 .53-1.27 1.0-1.3 1.1-1.9
PID LOAD Percent (7) 10-20 20-31 25-52
PID MISF OFF-ON OFF OFF OFF OFF
PID OCTADJS NO RETARD/RETARD NO RETARD NO RETARD NO RETARD NO RETARD
PID RPM RPM 0 750-820 1400-1630 1700-2100
(1) Steering wheel turned.
(2) Downstream O2S(s) will stay close to a constant voltage when catalyst monitor is off (positive value only). When catalyst monitor is on, O2S will switch rich to lean above and below .45 volt DC and never be a negative value.
(3) Value is dependent upon ambient air temperature and may fall outside of range.
(4) A/C on.
(5) O2S should switch from rich to lean at least once every 3 seconds. O2S voltage should toggle above and below .45 volt DC and never be a negative value. Valid O2S switching only occurs during closed loop fuel control.
(6) Clutch pedal applied.
(7) Value is not useful under this condition.
ESCORT 2.0L 4V M/T - OUTPUTS

PCM Pin No./PID Only Actuators/Outputs Units Measured/PID KOEO/PID Hot Idle/PID 30 MPH/PID 55 MPH/PID
2 MIL DCV/OFF-ON .1/OFF VBAT/OFF VBAT/OFF VBAT/OFF
17 HFC DCV/OFF-ON VBAT/OFF .1/ON (1) VBAT/OFF VBAT/OFF
26 CDA DCV VBAT VBAT VBAT VBAT
44 VCT DCV VBAT VBAT 10.5-VBAT 10.5-VBAT
45 LFC DCV/OFF-ON .1/OFF VBAT/ON (1) .1/OFF .1/OFF
48 CTO Hz 0 25-38 37-48 72-85
52 CDB DCV/Percent VBAT VBAT VBAT VBAT
56 EVAPPDC Hz/Percent 0 0-10/0-100 0-10/0-100 0-10/0-100
67 EVAPCV Hz/Percent 0 0-10/0-100 0-10/0-100 0-10/0-100
69 WAC DCV/OFF-ON .1/OFF VBAT/ON (2) .1/OFF .1/OFF
72 SIL DCV VBAT VBAT VBAT VBAT
74 INJ3 mS 0 3.3-3.7 4.1-8.0 4.4-10.1
75 INJ1 mS 0 3.3-3.7 4.1-8.0 4.4-10.1
80 FP DCV/Percent 3.7/75 1.5/33 1.5/33 1.5/33
83 IAC DCV/Percent VBAT/0 9-10/20-40 8.0-11.1/34-40 6-7/45-55
93 HTR11 DCV/OFF-ON .1/ON (3) .1/ON .1/ON .1/ON
95 HTR12 DCV/OFF-ON .2/ON (3) .2/ON .2/ON .2/ON
100 INJ4 mS 0 3.3-3.7 4.1-8.0 4.4-10.1
101 INJ2 mS 0 3.3-3.7 4.1-8.0 4.4-10.1
PID FUELPW1 mS (4) 3.3-3.7 4.1-8.0 4.4-10.1
PID LONGFT1 Percent -20 To +20 -20 To +20 -20 To +20 -20 To +20
PID SHRTFT1 Percent (4) -10 To +10 -10 To +10 -10 To +10
PID SPARKADV Degrees 0 15-22 28-35 25-35
55 KAPWR DCV VBAT VBAT VBAT VBAT
71 VPWR DCV VBAT VBAT VBAT VBAT
90 VREF DCV 5 5 5 5
(1) Cooling fan on (single, low or high speed).
(2) A/C on.
(3) May change state under this condition.
(4) Value is not useful under this condition.
NOTE: All generic OBD-II readings under no load (Park or Neutral).
ESCORT 2.0L 4V A/T - GENERIC OBD-II PID VALUES

PID Measured Units Hot Idle 2500 RPM
LONGFT1 Percent -20 To +20 -20 To +20
LOAD Percent 32-38 16-20
MAF Grams/Sec. 2.6-2.7 7.2-8.0
SHRTFT1 Percent -10 To +10 -10 To +10
SHRTFT11 Percent -10 To +10 -10 To +10
SHRTFT12 Percent 95-100 95-100
SPARKADV Degrees 15-20 25-32
scientia non olet · About LEMON Manuals